FREE CONTENT

CBPCA Improves a Home Energy Home

September 01, 2005
September/October 2005
This article originally appeared in the September/October 2005 issue of Home Energy Magazine.
SHARE
Click here to read more articles about Training and Certification

        As was described in the last issue of Home Energy, Carol Markell, the magazine’s advertising and marketing manager, had volunteered her house for use during a training for the California Building Performance Contractors Association (CBPCA), a nonprofit organization that introduces contractors—and the general public— to home performance services (see “Training Day,”HE July/August ’05, p. 24). During the training, Markell’s house was run through several diagnostic tests, which tested her home’s performance while educating building contractors on the process of building performance testing.
        About a month after the training was completed,CBPCA trainers Rick Chitwood and Tim Locke and students returned to Markell’s Kensington, California, home to conduct a complete energy-feature retrofit. The home received a new heating system, a new duct system, a new water heater, a new gas dryer,warm floors in the bathroom, a quiet bathroom exhaust fan, infiltration reduction, high-efficiency air filtration, insulation in the ceiling and stemwalls, a lighting improvement, and a cleaned and sealed crawlspace (see “Test-Out Results”).
        Robert Mitchell and his crew were responsible for the job and the paperwork. It’s hard to say whether having two instructors and 16 new home performance contractors at the job was a help or a hindrance, but Mitchell managed to complete the retrofit in the allotted three days.
        “It was all done pretty much how Rick explained it to me,” says Markell. “The crawlspace was [finished] much more completely than I realized [with an added vapor barrier]. They put a lock on the crawlspace access so that no one could get into it, like animals. The new gas dryer was put on a pedestal and the duct for the dryer is much improved. My clothes dry in under one hour; before, it could take three hours.”
        The old 80,000-Btu furnace was replaced with a 15,000-Btu/hr combined hydronic air handler that is run off the water heater.“Rick warned me that it may take longer to heat up the home in the morning due to the smaller furnace, but it actually heats up faster,” Markell said.
        The goal of the improvements was to enhance comfort and reduce energy bills. The predicted space heating reduction is 78% (from $406 per year to $90 per year) and the total bill reduction is predicted to be 48% (from $850 to $443 per year).To take full advantage of the improvements, a list of system operation recommendations was provided. CBPCA recommended that Markell keep the bedroom doors open as much as possible, so that air supplied to each bedroom can get back to the return grille in the hall. Opening interior doors also allows for better temperature communication between the bedrooms and the thermostat in the hall.When windows are opened in the summer, both of the thermostats should be switched off.
        To remove moisture from the bathroom, CBPCA recommended that the bathroom exhaust fan always be used when showering. (“I have to remember to turn on the bathroom fan,” admits Markell.) The twist timer should be set to run the fan after a shower for 15 minutes or more (except in the summer when the windows are open and the floor heat
and furnace are off). One possible future improvement could be to replace the bathroom fan twist timer control with a control system that could cycle on the fan to provide whole-house ventilation, humidity control, or carbon-dioxide-level control if further improvement in the indoor air quality were desired.
        The fireplace damper should be kept closed except when the fireplace is used. Phantom loads from the audio/video equipment in the living room and the computer equipment in the shed could be eliminated by placing them on a switched plug strip that is switched off between uses.
        Markell had computer equipment in the shed; CBPCA recommended that she move the equipment into the house. Heating the shed with an electric heater is 2.6 times as expensive as the gas heat in the house. In addition, kitchen ventilation could be improved by installing a range hood when Markell remodels the kitchen.
        For the next year, CBPCA asked Markell to mail a copy of her monthly utility bill to Rick Chitwood at CBPCA. This will ensure that any problems with the heating system or system operation are identified in a timely manner.
        To maintain the new heating system, CBPCA recommends that Markell replace the 24 inch x 24 inch x 2 inch air filter at the return air grille once per year in the fall. When she is changing the filter, it is recommended that she also vacuum out the supply boots.The crawlspace should be checked once per year for signs of moisture, infestations, or odor. The crawlspace should be kept closed and locked at all times to prevent damage to the duct system, insulation, and vapor barrier. Finally, sediment should be flushed from the bottom of the water heater once per year and maintenance required by the water heater manufacturer should also be performed.
        Markell has already noticed positive changes in the house.“The house temperature is much more even.The bathroom floor is wonderful. The house was not hot [in June] when it was hot out. But I’m interested in seeing what happens during a three- or four-day heat wave.”

  • 1
  • FIRST PAGE
  • PREVIOUS PAGE
  • NEXT
  • LAST
Click here to view this article on a single page.
© Home Energy Magazine 2014, all rights reserved. For permission to reprint, please send an e-mail to contact@homeenergy.org.
Discuss this article in the Trainers and Mentors group on Home Energy Pros!

Comments
Add a new article comment!

Enter your comments in the box below:

(Please note that all comments are subject to review prior to posting.)

 

While we will do our best to monitor all comments and blog posts for accuracy and relevancy, Home Energy is not responsible for content posted by our readers or third parties. Home Energy reserves the right to edit or remove comments or blog posts that do not meet our community guidelines.

Related Articles
Email Newsletter

Home Energy E-Newsletter

Sign up for our free monthly
E-Newsletter!

Harness the power of
HOME PERFORMANCE!

Get the Home Energy
e-newsletter

FREE!

SUBSCRIBE

NOW!